ABR 圓柱形自愈式低壓并聯電容器用于頻率50Hz或60Hz低壓電力系統設備的功率因數校正，適用于常規就地補償和集中自動補償，能夠減少無功損耗、改善電壓質量，是國家大力推薦的節能產品。 本產品符合標準：GB/T 12747，IEC831-1/2。
適用范圍 Scope of application
ABR 圓柱形自愈式低壓并聯電容器用于頻率50Hz或60Hz低壓電力系統設備的功率因數校正，適用于常規就地補償和集中自動補償，能夠減少無功損耗、改善電壓質量，是國家大力推薦的節能產品。
本產品符合標準：GB/T 12747，IEC831-1/2。
ABR cylindrical self-healing low-voltage shunt capacitor is used for power factor correction of equipment in low-voltage power system with frequency 50Hz or 60Hz, applicable to conventional local compensation and centralized automatic compensation, which can reduce reactive power loss and improve voltage quality, and is an energy-saving product strongly recommended by the state.
This product conforms to the standard: GB/T 12747, IEC831-1/2.
型號及其含義 Model number and its meaning
正常工作條件 Normal working conditions
◇ 電容器從電源切除后一定要保證電容器剩余電壓降至10% 額定電壓才允許再次投入，通常情況這個時間約需200s，所以控制器要選用帶有切除后再投入有再投鎖定時間功能的控制器。如果采用一般控制器，要另裝快速放電設施。對于采用等電位投切開關的可以不受此限。
◇ 海拔高度不超過2000m。
◇ 環境溫度類別-25/C，最低溫度-25℃，最高溫度C 類，( 最高不超過50℃，24 小時內溫度平均值不超過40℃，一年內溫度平均值不超過30℃ )。電容器應保證在良好的通風條件下工作，不允許在密閉不通風環境下工作。
◇ After the capacitor is removed from the power supply, it must be ensured that the remaining voltage of the capacitor drops to 10% of the rated voltage before it is allowed to be put in again. If the general controller is used, a separate fast discharge facility should be installed. For the use of equipotential throwing switch can not be subject to this limit.
◇ The altitude should not exceed 2000m.
◇ Ambient temperature category -25/C, minimum temperature -25 ℃ , maximum temperature category C, (maximum not more than 50 ℃ , average temperature not more than 40 ℃ in 24 hours, average temperature not more than 30 ℃ in a year). Capacitors should be guaranteed to work under good ventilation conditions, and are not allowed to work in a confined and non-ventilated environment.
結構特征 Structural features
◇ 采用圓柱形鋁罐封裝。
◇ 浸漬劑為無公害絕緣油。
◇ 內置壓力分離裝置及放電電阻。
◇ 電容芯子采用自愈式優質金屬化聚丙烯薄膜。
◇ 電容器頂部為防觸電接線端子。
◇ 電容器底部為M12 或M16 安裝及接地螺栓。
◇ 三相電容器內部均為△接法。
◇ Packaged in a cylindrical aluminum can.
◇ The impregnating agent is pollution-free insulating oil.
◇ Built-in pressure separation device and discharge resistor.
◇ The capacitor core is made of self-healing high-quality metallized polypropylene film.
◇ The top of the capacitor is an anti-touch terminal.
◇ The bottom of capacitor is M12 or M16 mounting and grounding bolt.
◇ Three phase capacitors are connected internally by △ method.
主要技術參數 Main technical parameters
◇ 額定電壓：0.23kV、0.25kV、0.4kV、0.415kV、0.45kV、0.48kV、0.525kV 等；
◇ 額定容量：1~30kvar；
◇ 電容量容差：-5%~+10%；
◇ 損耗角正切：tanδ ≤ 0.1%；
◇ 極間耐壓：2.15 倍額定電壓5 秒，無永久性擊穿或閃絡；
◇ 絕緣水平：極殼間加電壓：2 倍額定電壓加2kV 或3kV 取較高者，歷時10 秒，無擊穿或閃絡。
◇ 最高允許電壓：1.1 倍電壓時，每24 小時中不超過8 小時；1.15 倍電壓時，每24 小時中不超過30 分鐘；
1.2 倍電壓時，不超過5 分鐘( 持續)：1.3 倍電壓時，不超過1 分鐘。
◇ 最大允許電流：允許不超過1.3 倍額定電流下運行，考慮到過電壓、電容正偏差及諧波的影響，過渡電流不超過1.43倍額定電流。
◇ 放電器件：內置放電電阻，電容器切斷電源后放電3 分鐘降壓至50V 以下。
◇ 符合標準：GB/T12747-2017，IEC60831-2002。
Cylindrical self -healing lo w-voltage shunt c apacitors
◇ Rated voltage: 0.23kV, 0.25kV, 0.4kV, 0.415kV, 0.45kV, 0.48kV, 0.525kV, etc.
◇ Rated capacity: 1~30kvar.
◇ Capacity tolerance: -5% to +10%.
◇ Loss angle tangent：tanδ ≤ 0.1%.
◇ Inter-pole withstand voltage: 2.15 times rated voltage for 5 seconds, no permanent breakdown or flashover.
◇ Insulation level: voltage between poles and shells: 2 times rated voltage plus 2kV or 3kV, whichever is higher, for 10 seconds, no breakdown or flashover.
◇ Maximum allowable voltage: not more than 8 hours in every 24 hours at 1.1 times the voltage; not more than 30 minutes in every 24 hours at 1.15 times the voltage.
At 1.2 times the voltage, not more than 5 minutes (continuous): at 1.3 times the voltage, not more than 1 minute.
◇ Maximum allowable current: Allowed to operate at no more than 1.3 times the rated current. Taking into account the effects of overvoltage, positive deviation of capacitance and harmonics, the transition current should not exceed 1.43 times the rated current.
◇ Discharge device: Built-in discharge resistor, capacitor discharges to below 50V for 3 minutes after cutting off power.
◇ Conform to the standard: GB/T12747-2017, IEC60831-2002.
0511-88223456
